Author |
Message |
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Sat Feb 13, 2016 1:36 pm Post subject: Re: Project 66 Daily Driver. |
|
|
Well during the break from being able to drive this car again, today on one of the coldest days of the year I pulled the drivers side headlight wiring harness out to repair the damage done to it last week.
Since it is so cold out I figured I could have it out in a few minutes and get back in the house to repair the wiring. Not the case, I didn't realize the horn wiring was part of it all and pulled the tank partially to get it all out. I lubed the wires up to get them to get them through the grommet that goes through the firewall.
To repair the harness I stripped the wire loom for the headlight wires, cleaned up the wires and added some insulation between them just in case the wire fire melted the original insulation. There was a good burn where the high and low beam wires go by the ground wire for the headlight. I fixed that as well. I had some original wiring left from Herbie when I replaced the complete harness so I was able to replace the grey wire with a grey with black strip. After a little cleaning with degreaser I cleaned most of the black off. I finished up by re wrapping the harness with electrical tape. Later Ill get some new wire loom and replace the grommets for this as well.
and of course I am working on the fusees also. I spliced in the original wiring plus the proper 8 amp fuse.
_________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044
Last edited by EA812 on Sun Feb 21, 2016 3:36 pm; edited 2 times in total |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
Ghia Nut Samba Member
Joined: December 23, 2003 Posts: 1565 Location: B'ham Alabama
|
Posted: Thu Feb 18, 2016 12:31 pm Post subject: Re: Project 66 Daily Driver. |
|
|
Still one of my favorite threads.
I really like how you just drive it and enjoy it as a car. There's no slammed suspension, overtly lopey massive engine, or super shiny bass boat paintjob, or look how many awards I got, or this is not the correct year only nut burried deep in some insignificant place, or some concourse elegance "yes its matching numbers", or its not rust its patina, or trailer Queen, or I have the only set of production wheels from some obscure manufacturer, or o have every option known to man out of the og empi catalogue before empi turned to shit, or this was actually imported before Ben pon imported the first beetles. And while a lot of people are into that, which that's cool I'm not judging here, it just kinda stands out to me.
While I do kind of enjoy threads and posts and discussions or rants like that this is kind of a breath of fresh air, work a little, drive a little, show interesting places type thread. I makes me realize how much a small part of owning a vw can be missed by all of these distractions. I think when I look back at 16-20 year old me I honestly would have said so what. Now that I'm turning 30 (I know that's still spring chicken to a lot of you guys) I'm beginning to understand that the small important things are what makes ownership and enjoyment really come from vs how can I make it beat a Honda.
Just wanted to say thanks and I'm headed to work on the Ghia tonight. |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Sat Feb 20, 2016 10:07 am Post subject: Re: Project 66 Daily Driver. |
|
|
iGha Nut wrote: |
Still one of my favorite threads.
I really like how you just drive it and enjoy it as a car. There's no slammed suspension, overtly lopey massive engine, or super shiny bass boat paintjob, or look how many awards I got, or this is not the correct year only nut burried deep in some insignificant place, or some concourse elegance "yes its matching numbers", or its not rust its patina, or trailer Queen, or I have the only set of production wheels from some obscure manufacturer, or o have every option known to man out of the og empi catalogue before empi turned to shit, or this was actually imported before Ben pon imported the first beetles. And while a lot of people are into that, which that's cool I'm not judging here, it just kinda stands out to me.
While I do kind of enjoy threads and posts and discussions or rants like that this is kind of a breath of fresh air, work a little, drive a little, show interesting places type thread. I makes me realize how much a small part of owning a vw can be missed by all of these distractions. I think when I look back at 16-20 year old me I honestly would have said so what. Now that I'm turning 30 (I know that's still spring chicken to a lot of you guys) I'm beginning to understand that the small important things are what makes ownership and enjoyment really come from vs how can I make it beat a Honda.
Just wanted to say thanks and I'm headed to work on the Ghia tonight. |
Well said Ghia Nut!
Its kind of like the saying " life is is a journey not a destination"
That being said Ill be continuing the journey today with our sudden warm temps here in the North East. Its 50 degrees out there now and my son and I have already gone out to do some birthday shopping and just enjoying the old car in general.
If you are able to take your Ghia to work now then enjoy the ride! _________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Sat Feb 20, 2016 9:02 pm Post subject: Re: Project 66 Daily Driver. |
|
|
What better car to take to get shirts with Beetle pictures on but a Beetle?
Last weekend I'm tearing wiring out of it then this weekend putting on 120 miles to and from Old Lyme CT for the CVA member dinner. This was the longest trip on the highway at night. I just haven't been on the highway so much at night with it. Good thing I got the headlight back together and working. I had to use the marker lights on the way down....
and I wasn't the only air cooled there!
_________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Sun Feb 21, 2016 11:22 am Post subject: Re: Project 66 Daily Driver. |
|
|
I finished up the wire loom. Since I had ten feet I did the other side also. I ran the wires for the signal lights into it also. Just need to get some smaller diameter loom to finish the job.
Oh yeah put the door card back on.. eh after heating and putting weight on it ... oh well it went right back to bent. after being that way for like thirty years that's how it will stay.
_________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Mon Feb 22, 2016 6:03 pm Post subject: Re: Project 66 Daily Driver. |
|
|
Ghia Nut wrote: |
Still one of my favorite threads.
I really like how you just drive it and enjoy it as a car. There's no slammed suspension, overtly lopey massive engine, or super shiny bass boat paintjob, or look how many awards I got, or this is not the correct year only nut burried deep in some insignificant place, or some concourse elegance "yes its matching numbers", or its not rust its patina, or trailer Queen, or I have the only set of production wheels from some obscure manufacturer, or o have every option known to man out of the og empi catalogue before empi turned to shit, or this was actually imported before Ben pon imported the first beetles. And while a lot of people are into that, which that's cool I'm not judging here, it just kinda stands out to me.
While I do kind of enjoy threads and posts and discussions or rants like that this is kind of a breath of fresh air, work a little, drive a little, show interesting places type thread. I makes me realize how much a small part of owning a vw can be missed by all of these distractions. I think when I look back at 16-20 year old me I honestly would have said so what. Now that I'm turning 30 (I know that's still spring chicken to a lot of you guys) I'm beginning to understand that the small important things are what makes ownership and enjoyment really come from vs how can I make it beat a Honda.
Just wanted to say thanks and I'm headed to work on the Ghia tonight. |
Such a good response from Ghia Nut that I had to reply again to some of my favorite parts of that post. Last week I was busy working on the car to get it ready for Saturdays trip south so I didn’t get the time to reply with full remarks.
1 just drive it and enjoy it as a car. There's no slammed suspension, overtly lopey massive engine, or super shiny bass boat paintjob, or look how many awards I got, or this is not the correct year only nut burried deep in some insignificant place, or some concourse elegance "yes its matching numbers",
I’m not a stickler for original stuff but I kind of go for a 74 with a 60s body. Like the previous owner of our 65 he kept switching things with the later model VW parts when he could.
12 V, 200 mm clutch, 1600 DP engine, duel master cylinder, 12V switches in the dash and we have the later 66 gas pedal in that car.
2 its not rust its patina, or trailer Queen, or I have the only set of production wheels from some obscure manufacturer, or o have every option known to man out of the og empi catalogue before empi turned to shit, or this was actually imported before Ben pon imported the first beetles. And while a lot of people are into that, which that's cool I'm not judging here, it just kinda stands out to me.
My intention was, one to use what I got and two try and go for that survivor look.
It also has 113000 original miles on it plus some unoriginal as well. no documentation to prove it had just 100000 on it when I got it but I was the first one to do things like pull the trans axle, replace three out of four ball joints. One was not OG. Lots of the original stuff was still with this car although warn or warn out.
While I do kind of enjoy threads and posts and discussions or rants like that this is kind of a breath of fresh air, work a little, drive a little, show interesting places type thread. I makes me realize how much a small part of owning a vw can be missed by all of these distractions. I think when I look back at 16-20 year old me I honestly would have said so what. Now that I'm turning 30 (I know that's still spring chicken to a lot of you guys)
3 I'm beginning to understand that the small important things are what makes ownership and enjoyment really come from vs how can I make it beat a Honda.
I’m just impressed at the fact one of these or any 40 plus year old car is still going. _________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Sun Mar 06, 2016 1:04 pm Post subject: Re: Project 66 Daily Driver. |
|
|
Just finished up the other headlight. The passenger side came out real nice. Not perfect but Id say 8 out of 10. Ive got a few lenses to work with but somehow that side looks real good. The drivers side I went too far buffing the chrome so I may got to anther one that I have or just end up replacing them later on and that one was never going to come out perfect anyhow.
The whole process started a few years ago when I was working on making these operational again and all the rubber pieces were dried up. I replaced them with some 1/8 inch interior sized fuel line that I had from NAPA.
_________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Wed Mar 16, 2016 10:25 am Post subject: Re: Project 66 Daily Driver. |
|
|
We had some real nice weather last week and I was fortunate to be able to take A- Bomb out five of seven days last week.
I spotted this baja beetle last week on my way to one of my favorite burger makers. When I come across another air cooled on the road I wonder whats going through the person's head behind me. "ugh another one of those?"
Also did some work on it during them nice temps. I stated earlier in the thread that "I purchased the cheap body seal kit from J Bugs." I didn't mean it the way that came out. It just wasn't the top seal kit that they had. So Ive been slowly swapping the things that have cracked since getting the car going. This past weekend I swapped out the signal light seals front and back with West Coast Metric seals. Ive had a rash of rubber failures on Herbie lately that I was under the impression were to be of quality so I'm only going with WCM from now on.
_________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Fri Apr 01, 2016 7:47 am Post subject: Re: Project 66 Daily Driver. |
|
|
A shot from last weeks opining night at the drive in Mansfield Drive In for Zootopia. We got there a little before it opened and I noticed this newer beetle in line ahead of us. Turned out to be another CVA club member.
Oh yeah somebody mentioned earlier in the thread that I don't post any pics of all the trophies I get for this car. I get one every time we take it out... I even got one for going to 7 Eleven.
These are some of the categories that I won a trophy from:
bought a second hand toaster
from a guy who says he knows Brad Pitt
My sister used to take piano lessons
From the second cousin of Ralph Nader
my birthday and Kim Kardashian's
Are exactly the same
I posted first in the comments
On a YouTube video
I know a guy who knows a guy who knows a guy
Who know a guy who knows a guy who know Kevin Bacon
This car used to belong
To Cuba Gooding Jr.'s uncle
Paul Giamatti's plumber knows me by name
One time I was in the checkout line
Behind Steven Seagal
I used the same napkin dispenser
As Steve Carell at a Taco Bell
HAPPY APRIL 1RST!!!!!!! _________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Fri Apr 15, 2016 7:40 am Post subject: Re: Project 66 Daily Driver. |
|
|
Recently I came across some service bulletins here on how to add a reverse light switch to pre 67 Beetles. It looked like a fun project and something I could fabricate. I split up a set of 67 reverse lights between our 65 and 66. a CVA member gave me them last year, complete with bulbs and they cleaned up nice.
I decided to try to make the style with the arm that attaches to the shift rod to push the switch when shifted to reverse. During some testing with thin sheet metal I found that there is only 10 millimeters difference between second gear and reverse with my version. The arm needed to go over the switch to not push it for second gear. I needed to find a small momentary on switch that doesn't need a lot of pressure to complete the circuit. I found one at Home Depot of all places. That and stuff I already had the reverse light switch cost me about 5 dollars.
.
Testing it looked good. I may switch the arm that pushes the switch. It was just temporary for now with a piece of sheet metal held on by a hose clamp but I liked the way it worked. I'll bet once I decide it all works good and put the cover on and seat back then it will stop working.
In the service bulletin it shows how to wire it up. I ran the wire a little differently because it was going to be just too much trouble to try to get the wire behind the tar board. If I take the engine out any time soon Ill reroute it. I also ran both wires through the Cables Exit Chassis Boot kind of using it like a grommet. From terminal 15 on the coil I added an inline fuse holder and ran the wire behind the carb like the instructions show, to the wire clamp on the fan shroud wrapped in a piece of rubber fuel hose. Then routed that wire through the hole where the wire to the voltage regulator used to go through the firewall tin ( Both cars are converted to 12V). For the momentary on switch I attached wire leads with bullet connectors to make it a little easier to work with and a little extra wire to complete circuit to route it under the shift rod in the tunnel. I also used about 15 feet of 14 gauge black wire. It looked like the same stuff the lights had in them.
Road testing it recently and it seems to work good. I was surprised how much light just one reverse light puts out.
Here is some reference to them bulletins:
http://www.thesamba.com/vw/archives/manuals/techbulletins/e3.php
http://www.thesamba.com/vw/forum/viewtopic.php?t=439716&highlight=reverse+light _________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
|
Back to top |
|
|
EA812 Samba Member
Joined: December 07, 2008 Posts: 1223 Location: North central, CT
|
Posted: Fri May 13, 2016 10:07 am Post subject: Re: Project 66 Daily Driver. |
|
|
Until today we have been enjoying some real terrific weather so Ive been out enjoying the old car every day since Saturday but no today. Saturday was a little wet but not a wash out so we took a trip out to Frog Rock 212 Pomfret Rd (Rt. 44) Eastford Ct.
Speaking of Frog Rock, On Saturday July 23rd, 2016 -The CVA’s 3rd Annual FROG ROCK Gathering from Noon till 3pm, Address: 212 Pomfret Rd (Rt. 44) Eastford Ct. 06242. A social event for all VW’s. Burgers, Hot Dogs, Seafood and Ice Cream available at the food stand. Next we head down the road to the Tri State Cruiser’s Saturday night cruise from 3 till dark at the junction of Rt.169 and Rt. 101, Pomfret Center. For more info please call: Bill Arute (860) 395-9964 [email protected] or Brent St Louis [email protected] _________________ Project 66 Daily Driver http://www.thesamba.com/vw/forum/viewtopic.php?t=538786&highlight=
Herbie build
http://www.thesamba.com/vw/forum/viewtopic.php?t=336044 |
|
Back to top |
|
|
|