Author |
Message |
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Sat Aug 20, 2016 7:31 am Post subject: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
This is a build thread on the 86 Westfalia I acquired after my 89 had a fire. Out of great sadness, joy!
djkeev PM'd me about this unit, 92k, very solid engine and transmission, super clean inside, new tires and rims, needs a new poptop tent, (which came with it,) and a bath. Had been sitting in Dave's yard for two years, came out to the East Coast from California three years ago. I contacted the very nice owner and bought it sight unseen.
My plan is to transplant my Bostig conversion and Transaxle from my '89, the fire was inside and nothing under it was affected. Some very lucky person will end up with the 86's 2.1L and tranny. The PO had bought a newly rebuilt ECU from GoWesty!
The van has new 16" tires on aluminum rims (5), and the owner gave me three new 16" tires on VW rims. My 89 has new GoWesty 15" Michelin tires and rims, so I have no need of these tires.
This will be a slow thread, I have to finish the garage cleanup and removal stuff.
The fire thread is here, that's where photos of my dismantling progress will be posted, not here.
http://www.thesamba.com/vw/forum/viewtopic.php?t=660443&start=0
Those who recall the complete rebuild on the 87 I did, here's that link:
http://www.thesamba.com/vw/forum/viewtopic.php?t=635850&highlight=
So now to the photos you're sitting on the edge of your seat awaiting----
Oh and it came with a Behr air conditioning system, which I know absolutely NOTHING about, but all A/C theory is the same, right?
and the journey begins...... _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
j_dirge Samba Member
Joined: August 08, 2007 Posts: 4641 Location: Twain Harte, CA
|
Posted: Sat Aug 20, 2016 9:55 am Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
"Every car has one.."
Nice find.
Looking forward to reading about and following your progress! _________________ -89 GL Westy, SVX.. finally.
-57 pan f/g buggy with a 67 pancake Type 3 "S"
"Jimi Hendrix owned one. Richard Nixon did not"
-Grand Tour, Season 1, episodes 4 and 5
danfromsyr wrote: |
those are straight line runs with light weight race cars for only 1/4mile at a time..
not pushing a loaded brick up a mountain pass with a family of 4+ inside expecting to have an event free vacation..
|
|
|
Back to top |
|
|
Stephenmarklay Samba Member
Joined: August 10, 2016 Posts: 526 Location: Spokane
|
Posted: Sat Aug 20, 2016 7:06 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
Sweet man. Good for you. _________________ 1985 Westfalia. Project 2017. |
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Sun Aug 21, 2016 4:10 pm Post subject: Checking it out |
|
|
Found time to look at the Westy, looks good.
Here's the stove/sink area
2.1L engine
No sign of oil leaks, etc underneath
Muffler is rusty, but quiet
The tent is shot full of holes, and a mouse had moved in upstairs, no photo.
First part of this will be to replace it, but working on the 89 first. _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
dobryan Samba Member
Joined: March 24, 2006 Posts: 16501 Location: Brookeville, MD
|
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Sun Aug 28, 2016 3:07 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
Well, this cherry has been burst! Found time to work on it, have to pass Mass auto inspection. One headlight didn't work, and the other one had an inch of water inside.
Pulled it apart and found some bizarro wiring system from the PO. I don't mind people doing their own thing, just wish they'd leave behind detailed notes.
The non-working headlight had a broken wire, Ah easy fix! Nope, wires are corroded and I'll have to re-wire everything. Wish me luck....
Here's a photo:
_________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32584 Location: Reading Pennsylvania
|
|
Back to top |
|
|
Paulbeard Samba Member
Joined: July 10, 2015 Posts: 2604 Location: Seattle
|
Posted: Sun Aug 28, 2016 3:35 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
Yuck. Get you to Jay Brown and get a new harness for the headlights, root out all that stuff. I hear there are some success stories getting E-code H4s installed, if you're interested. _________________ Currently -> Frida: 87 Tizian Red (mostly) Vanagon GL Westfalia w/ 2.0L ABA conversion
Formerly -> Steward of a 73 Super Beetle (Beater) and 67 Beetle 1300 (Little Max) both names by POs
— dhaavers |
|
Back to top |
|
|
fxr Samba Member
Joined: December 07, 2014 Posts: 2321 Location: Bay area CA
|
Posted: Sun Aug 28, 2016 4:01 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
Those look like they might be HID lights - is that the ballast on the left? _________________ Jim Crowther
1984 1.9l EJ22 Westy Wolfsburg Edition
Vespa GTS 300 |
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Sun Aug 28, 2016 5:17 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
I'll sort it out, I have an electronics background via ham radio and commercial work. I rewired most of the 87 I rebuilt.
Dave, I haven't had time to dig deep yet, maybe the headlights are an anomaly! _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32584 Location: Reading Pennsylvania
|
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Sun Aug 28, 2016 6:25 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
Dave,
I feel the same way. _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Mon Aug 29, 2016 11:34 am Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
I removed the old headlight wiring system. Does anyone use this system and wants these parts? Just pay for postage....
I traced back the wiring to the fuse panel. A VOM (Volt-Ohm Meter) is a must have tool for this work.
You didn't get to see all the "extra" wires I removed. BTW, don't use wire nuts on an automobile. Connectors that crimp in-line are my preferred method, then install heat shrink tubing over them. Some come pre-made with heat shrink.
I took the lights from my 89 and used them here. I installed a new Jay Brown headlight relay, which is safer and allows higher wattage bulbs. You don't overload the VW light switch, either!
Then I replaced the side marker lights and rear tail lights with ones from the '89. These are all LED bulbs I'd bought from GoWesty. Still have one side marker light not turning on, will look at that tomorrow, have to work tonight.
Inspection tomorrow, if the lights can stay on for 10 minutes...... _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32584 Location: Reading Pennsylvania
|
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Mon Aug 29, 2016 2:47 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
Dave,
No, not even sure how to remove them, but good idea, I'll consider doing it.
Jeff
Any other thoughts? Tomorrow is tent installation Day! _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Tue Aug 30, 2016 11:06 am Post subject: Tent going in |
|
|
All electrical items working as specified. Waiting for 9/1 to do the inspection, may as well have an extra month.
Started on the new popup tent going in. The old one removed easily, I carefully labeled what went where.
Then meandered off to the fabric store to get something to make new curtains. One should always compliment the colors that are there, not do same-same. While the picture doesn't do this nice cloth justice, you can see how the floor follows the decorating rule I just cited.
I live on a lake and the beach is calling my name...... _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Sun Sep 04, 2016 3:13 pm Post subject: Tent finished |
|
|
Well, I installed the tent, what a PITA. The PO sold me the tent he bought new from Bus Depot, most likely two years ago. I couldn't get it to fit, and kept thinking it was my fault. After several re-tries, turns out it's 8 inches too short. There are nylon cords that lock in the tent top, these stuck out about the exact distance needed to make it fit. I'm not happy with BD!
So, I tossed the directions out and did it my way. Had to cut the back section and add a panel about 8 inches wide. Yes, it'll work fine, and match the new curtains. (When I get around to sewing them....)
What the old tent looked like:
And the new now:
I put on the air scoops and the Jack Bombay lifts. I can't live without the latter, they're great for my back.
Til next time..... _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32584 Location: Reading Pennsylvania
|
|
Back to top |
|
|
JudoJeff Samba Member
Joined: May 24, 2013 Posts: 1179 Location: Near Springfield, MA
|
Posted: Sun Sep 04, 2016 3:38 pm Post subject: Re: Arise from the Ashes-Cherry 86 Westy getting a Bostig Transplant |
|
|
Were the customers turning rabid? I can understand why...
I sew, and when I read about the tents not fitting, my thought was they might be off by one inch. The glaring error I had screams "incompetent ".
Oh, and the zippers suck! _________________ ________________________________________
1989 Vanagon GL Westfalia Camper, Burned up on 7/31/16.
1987 Vanagon GL Westfalia Camper, Bostig & Rebuilt, sold
1986 Vanagon GL Westfalia Camper, Bostig Sold May 10, 2021
1999 Ford GTRV Westfalia camper (30% bigger Westy layout) |
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32584 Location: Reading Pennsylvania
|
|
Back to top |
|
|
|