Author |
Message |
Mikedrevguy Samba Member
Joined: October 15, 2008 Posts: 2240 Location: Medford, OR
|
Posted: Thu Mar 29, 2018 10:27 am Post subject: 1976 914 Alternator Light |
|
|
Situation- alternator not charging and light not lighting at startup.
If I externally ground the light, it will light, but, s not grounded on its own.
Where would I check this for the bad ground?
Thanks _________________ 74 1303 (RevBug): plan for German Look
76 914 with 2260
79 VW Iltis
69 Bwajaja
"The wise speak because they have something to say; while the foolish speak because they have to say something." Plato
Illigitimi non-Carborundum!! |
|
Back to top |
|
|
Starbucket Samba Member
Joined: April 30, 2007 Posts: 4026 Location: WA
|
Posted: Fri Mar 30, 2018 1:07 pm Post subject: Re: 1976 914 Alternator Light |
|
|
I believe it doesn't use a ground as it just completes the circuit so if bulb is burned out = no charge. Check your alt. brushes. |
|
Back to top |
|
|
Mikedrevguy Samba Member
Joined: October 15, 2008 Posts: 2240 Location: Medford, OR
|
Posted: Fri Mar 30, 2018 1:28 pm Post subject: Re: 1976 914 Alternator Light |
|
|
Bulb is not burned out. Have checked with known good bulb and socket.
Key on- alt- light does not light. _________________ 74 1303 (RevBug): plan for German Look
76 914 with 2260
79 VW Iltis
69 Bwajaja
"The wise speak because they have something to say; while the foolish speak because they have to say something." Plato
Illigitimi non-Carborundum!! |
|
Back to top |
|
|
Starbucket Samba Member
Joined: April 30, 2007 Posts: 4026 Location: WA
|
Posted: Fri Mar 30, 2018 3:14 pm Post subject: Re: 1976 914 Alternator Light |
|
|
Trace the wires looking for bad connection, if all good take alt. to flaps and get it tested. |
|
Back to top |
|
|
Mikedrevguy Samba Member
Joined: October 15, 2008 Posts: 2240 Location: Medford, OR
|
Posted: Fri Mar 30, 2018 3:46 pm Post subject: Re: 1976 914 Alternator Light |
|
|
Starbucket wrote: |
Trace the wires looking for bad connection, if all good take alt. to flaps and get it tested. |
Thanks. _________________ 74 1303 (RevBug): plan for German Look
76 914 with 2260
79 VW Iltis
69 Bwajaja
"The wise speak because they have something to say; while the foolish speak because they have to say something." Plato
Illigitimi non-Carborundum!! |
|
Back to top |
|
|
Starbucket Samba Member
Joined: April 30, 2007 Posts: 4026 Location: WA
|
Posted: Sat Mar 31, 2018 2:12 pm Post subject: Re: 1976 914 Alternator Light |
|
|
Check autohauseaz.com if you need parts. |
|
Back to top |
|
|
[email protected] Samba Member
Joined: December 28, 2016 Posts: 280 Location: atlanta ga
|
Posted: Mon Apr 02, 2018 11:00 am Post subject: Re: 1976 914 Alternator Light |
|
|
make sure that you have power to the red with white that connects to the bulb, go to the blue wire and first check to see, with the key in the on position if you have a ground. If not, go to the front of the relay board in the engine compartment, remove the two rear phillips screws and back the board back, pry off the top exposing the two rows of pins like eggs in a carton, hook your test light to the positive post of the battery, pull the bulb out of the alt light socket and see if the blue wire is grounded. If it is there is a break, if it is not then substitute the voltage regulator. If that does not make a difference then replace the alternator. Make sure that the alternator harness is firmly plugged into the replay board and properly connected to the back of the alternator. |
|
Back to top |
|
|
Mikedrevguy Samba Member
Joined: October 15, 2008 Posts: 2240 Location: Medford, OR
|
Posted: Mon Apr 09, 2018 10:04 am Post subject: Re: 1976 914 Alternator Light |
|
|
thanks for the direction. so far haven't gotten past discovering that the blue white is NOT grounded with the key is on (or at least it is a very intermittently poor ground.
discovered a bit of a rats nest behind the instrument cluster. surprise surprise.
biggest so far was the terminal ends of the red/white power wires taped to the lead of a blue/yellow. Blue/yellow dives back into the wiring harness taped together. has micro spade connector, but these were taped with electrical tape.
any suggestions/hints on what this might be connected to?
also, there's a stray black/yellow strip wire. it, too, has a micro spade connector/
thanks again.
Mike _________________ 74 1303 (RevBug): plan for German Look
76 914 with 2260
79 VW Iltis
69 Bwajaja
"The wise speak because they have something to say; while the foolish speak because they have to say something." Plato
Illigitimi non-Carborundum!! |
|
Back to top |
|
|
|