93 Eurovan CL to Westfalia CV Conversion

[Zeitgeist 13]

Thanks so much for these informative pics. Is that sunroof standard on the CV model tops?
_________________
Casey--

'89 Bluestar ALH w/12mm Waldo pump, PP764 and GT2052
'01 Weekender --> full camper
y u rune klassik?

[spou-unit]

Sunroof was installed by previous owner.

[spou-unit]

Got the carpet and subfloor up

[IdeaNerd]

+1 re: thanks for posting the pics. Very interesting and informative! Please keep them coming.

[CdnVWJunkie]

Seeing all of the rot in the rear floors and the rear side walls I think you have made a very wise decision to strip it for parts.

[Gruppe B]

Use heat to remove the aluminum seat rail tracks. They are stuck down using a polyurethane type adhesive. If you use heat and a scraper they will pop right off.

Not sure what adhesive to use to reattach. I am looking at this too with my CV interior....

[spou-unit]

Managed to get the seat rails strip up. Used a MAP gas torch and an olfa knife and got er.

[Gruppe B]

Are you going to install the Eberspacher underfloor gas heater to the new Van?

[spou-unit]

Hey all. Been a while since posting. Haven’t had time for any work.

Finally got around to placing the seat rails and testing carpet fit.

I took measurements from old van and lined up rails in new van. Then drilled a couple of holes for locating rails, screwed down and checked carpet fit.

Now to remove, clean and glue in place.

Still have to drill some holes and put in riv-nuts before I can glue carpet.

And also need to do something about the heater core which will be covered by the carpet when it’s laid in place.

[Euro1]

Great work! I sent you a pm!

[spou-unit]

Ok it’s been a while. I urethaned the seat rails down today. It’s a start!

The seat fits!

[spou-unit]

Ok so I hauled out the rear wiring harness from the red westfalia.

This connects to some connectors that come out of the pillar by the drivers sunshade.

This is for a number of things, from the cooler box to the display overhead of driver, water pump, yada yada

[Gruppe B]

Thanks for the updates!
I need to do the same install for my Eurovan CV rear bench.

Does your Westfalia have the underfloor eberspacher heater and if so are you going to install in the new van?

Cheers
Gruppe B

[spou-unit]

I got some tires switched onto the rims.

[spou-unit]

Now just gotta get the two front tires switched over.

[IdeaNerd]

Glad to see the updates! Please keep them coming. : )

[spou-unit]

Added some pics of what it’s like underneath. Compared to “Old Red”, she’s a dream. Gotta get under and give her a scrape and hit with rust converter.

[spou-unit]

Front bumper installed and rear wiring harness mostly installed.

[murso74]

so were there campervans that were SWB outside of the US?

[Gruppe B]