Author |
Message |
gprteau Samba Member
Joined: August 26, 2018 Posts: 1 Location: Portland, OR.
|
Posted: Sun Aug 26, 2018 11:39 am Post subject: Coolant hose bleeder |
|
|
Hello all,
My 84 Westy is leaking coolant. I believe that I have traced the leak to the Coolant hose bleeder. I cannot see a crack but it is obviously leaking from the bottom of the bleeder. I have two questions that I hope people can help me with.
1. I see there are plastic and aluminum replacements. What are the pros and cons between the two? The one in there is plastic. I do not know when it was last replaced if at all.
2. If I choose to replace this myself is there anything else to it then just removing the old part and putting in the new one? It seems pretty straight forward. Make sure it clips in and some hose clamps. Do I need to adjust anything?
Any advice would be welcomed.
Thanks,
Greg
1984 Westfalia WC |
|
Back to top |
|
|
Mellow Yellow 74 Samba Member
Joined: October 14, 2014 Posts: 1615 Location: Sydney, Australia
|
Posted: Mon Aug 27, 2018 2:39 am Post subject: Re: Coolant hose bleeder |
|
|
The aluminium ones will last for ever but are expensive, they come with the auto hose connections so you need to blank these off if you have a manual.
The plastic ones are much cheaper but they could fail again in future and only the manual version is available.
I have an auto but have replaced the transmission cooler with the heat sink type so I used a manual version plastic one. _________________ 1962 Karmann Ghia
1974 Deluxe Microbus
1985 Caravelle (Vanagon) |
|
Back to top |
|
|
tencentlife Samba Member
Joined: May 02, 2006 Posts: 10067 Location: Abiquiu, NM, USA
|
Posted: Mon Aug 27, 2018 6:47 am Post subject: Re: Coolant hose bleeder |
|
|
Mellow Yellow 74 wrote: |
The aluminium ones will last for ever but are expensive, they come with the auto hose connections so you need to blank these off if you have a manual.
The plastic ones are much cheaper but they could fail again in future and only the manual version is available.
I have an auto but have replaced the transmission cooler with the heat sink type so I used a manual version plastic one. |
Definitely spring for the aluminum one, it doesn't have the weak point that ruins the plastic ones, the stupidly designed bleeder nipple cast of the same plastic. A metal threaded fitting there would have made the factory nylon ones last nearly forever, but they all break there.
But if you buy the alu one and don't have an auto-trans, don't trust the rubber nipple caps that may be included, they aren't rated for hot coolant service and will fail quickly. If the seller hasn't changed their practice and tapped those nipples for threaded metal plugs, do so yourself before installation. _________________ Shop for unique Vanagon accessories at the Vanistan shop:
https://intrepidoverland.com/vanistan/
Please don't PM here, I will not reply.
Experience is kryptonite to doctrine. |
|
Back to top |
|
|
msinabottle Samba Member
Joined: September 20, 2005 Posts: 3492 Location: Denver Area, Colorado
|
Posted: Tue Aug 28, 2018 5:32 pm Post subject: Re: Coolant hose bleeder |
|
|
The aluminum bleeder fitting I bought from the old Van Cafe, and which is sold by the new Van Cafe, comes with clamps and a hose connecting the two 'auto' nipples.
Notwithstanding that--it still leaked! This drip came from a loose clamp on the 'blank off' hose, tightened that yesterday. I installed an RMW metal tank and that fitting, and 'The German Water-and-Antifreeze Torture' has gone on all summer. Drip, drip, drip from different connections. Get those hose clamps TIGHT, folks, and remember that the geometry of the hoses changes a bit.
Other than that, both the tank and the junction/bleeder are good products and Mike LaBate himself answered a question I had on the bleeder. You bleed from the metal fitting by loosening a bolt over a blob of sealant with a wrench. That hasn't leaked a drop.
Best! _________________ 'Winston,' '84 1.9 WBX Westy
Vanagon Poet Laureate: "I have suffered in
many ways, but never, never, never in silence." |
|
Back to top |
|
|
|