Author |
Message |
Scheffro Samba Member
Joined: August 17, 2021 Posts: 3 Location: Carlisle, PA
|
Posted: Tue Aug 17, 2021 5:54 pm Post subject: Front Fan Blower Resistor Value |
|
|
Does Anybody know what the resistor value is?
I could make my own wire and resistor I'm missing this part.
Back story: Trying to fix my 2nd van! Someone in my neighbor hood report an abandon vehicle. I have till the 30th to get her going. I could put antique tags on the van. I'm not sure in pa if you can transfer the title back to a regular tag? I may want to daily it someday after I fix it up! |
|
Back to top |
|
|
Corwyn Samba Member
Joined: December 29, 2009 Posts: 2238 Location: Olympia, Washington
|
Posted: Tue Aug 17, 2021 6:20 pm Post subject: Re: Front Fan Blower Resistor Value |
|
|
Resistor for what? Front blower? Rear blowers (Westy)? A little more informantion. . . . _________________ '90 White Westy ("The Longship")
FAS Gen V 2.0
The Annual Baja Rally
https://www.thesamba.com/vw/forum/viewtopic.php?t=604813&highlight=baja
"If anything's" gonna happen, it's gonna happen out there"
~ Captain Ron ~ |
|
Back to top |
|
|
Scheffro Samba Member
Joined: August 17, 2021 Posts: 3 Location: Carlisle, PA
|
Posted: Wed Aug 18, 2021 2:25 pm Post subject: Re: Front Fan Blower Resistor Value |
|
|
Yes Front Blower. Its in the title.
The shop manual doesn't tell me what the resistance should be. It just states a series resistor....
Also, does anybody know if I can buy the metal clips to put the Front air box back together? |
|
Back to top |
|
|
jimf909 Samba Member
Joined: April 03, 2014 Posts: 7477 Location: WA/ID
|
Posted: Wed Aug 18, 2021 4:26 pm Post subject: Re: Front Fan Blower Resistor Value |
|
|
These?
https://www.vancafe.com/321819059-p/321819059.htm
I believe all the rage nowadays is to replace the resistor with a pwm control.
Link
_________________ - Jim
Abscate wrote: |
Do not get killed, do not kill others.
|
Current: 1990 Westy Camper - Bostig RG4, 2wd, manual trans w/Peloquin, NAHT high-top, 280 ah LFP battery, 160 watts solar, Flash Silver, seam rust, bondo, etc., etc.
Past: 1985 Westy Camper - 1.9 wbx, 2wd, manual trans, Merian Brown, (sold after 17 years to Northwesty who converted it to a Syncro). |
|
Back to top |
|
|
Scheffro Samba Member
Joined: August 17, 2021 Posts: 3 Location: Carlisle, PA
|
Posted: Wed Aug 18, 2021 5:23 pm Post subject: Re: Front Fan Blower Resistor Value |
|
|
Thanks! Those are the clips.
PWM is interesting. Maybe I will just add wires to the motor and run them out of the air box and figure it out later. I really just need the heater core in so I can fill the system with coolant. |
|
Back to top |
|
|
dhaavers Samba Member
Joined: March 19, 2010 Posts: 7757 Location: NE MN (tinyurl.com/dhaaverslocation)
|
Posted: Wed Aug 18, 2021 8:51 pm Post subject: Re: Front Fan Blower Resistor Value |
|
|
IIRC, it's roughly 2 ohms for low speed & 1 for medium. Full voltage for high speed. The original resistor
is ceramic, built to handle about 10 to 15 amps (!!!)...I've since replaced mine with a cheaper Jeep part:
https://www.thesamba.com/vw/forum/viewtopic.php?t=623382
- Dave _________________ 86 White Wolfsburg Westy Weekender
"The WonderVan"
<EDITED TO PROTECT INNOCENT PIXELS> |
|
Back to top |
|
|
danfromsyr Samba Member
Joined: March 01, 2004 Posts: 15144 Location: Syracuse, NY
|
Posted: Wed Aug 18, 2021 10:35 pm Post subject: Re: Front Fan Blower Resistor Value |
|
|
the resistor only creates the slower speeds.
you can wire it directly w/o a resistor and it'll be full speed.
you can then at your leisure add in a PWM unit to that single wire and control the fan motor speed.
much better to use a PWM than a resistor that creates alot of heat and wasted energy in the wiring system.
and a note to those who would want to upgrade to a PWM you do not need to open the dash and heater to remove the old resistor.
you can do all of your new speed control on the single wire that is/was the full fan speed wire.. leave that dead ceramic cigar in there. _________________
Abscate wrote: |
These are the reasons we have words like “wanker” |
|
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32632 Location: Reading Pennsylvania
|
|
Back to top |
|
|
|