Author |
Message |
dieseltdi Samba Member
Joined: September 07, 2006 Posts: 538 Location: Grapevine, Texas
|
Posted: Wed Jun 22, 2022 12:57 pm Post subject: Behr front AC unit questions |
|
|
Ok, I have finished my refurbishment of the Behr AC unit for my Vanagon. I have managed to decipher all the wiring using the manual that is available here on the SAMBA BUT I have two things that I need to know from you guys that have these units or have worked on them. 1) Anyone have the template for cutting the holes for the AC lines to pass through the front of the Vanagon or at the very least measurements of where the holes are? and 2). I have one extra wire that is not shown on the wiring diagram. The wiring diagram shows a 4 position fuse block with only 3 fuses present. My wiring there is pretty standard and matches the wiring diagram. However, I have a 4th fuse with a single heavy (possibly 12 gauge) red with white stripe wire that is about 6" long with a female terminal on the end. It is in continuity with the battery power wires that power the other fuses but no clue as to where it goes. My old Air cooled unit doesn't have any such wire. Anyone have a clue? Thanks for the help if you can give it. Hayden |
|
Back to top |
|
|
dieseltdi Samba Member
Joined: September 07, 2006 Posts: 538 Location: Grapevine, Texas
|
Posted: Thu Jun 23, 2022 8:01 pm Post subject: Re: Behr front AC unit questions |
|
|
I know from reading various threads on here that there are a number of folks that have installed or have an original install of these units. Can't someone help me out with a template or measurements? |
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32635 Location: Reading Pennsylvania
|
|
Back to top |
|
|
ALIKA T3 Samba Member
Joined: July 30, 2009 Posts: 6361 Location: Honolulu,Hawaii and France
|
Posted: Fri Jun 24, 2022 12:14 pm Post subject: Re: Behr front AC unit questions |
|
|
dieseltdi wrote: |
Ok, I have finished my refurbishment of the Behr AC unit for my Vanagon. I have managed to decipher all the wiring using the manual that is available here on the SAMBA BUT I have two things that I need to know from you guys that have these units or have worked on them. 1) Anyone have the template for cutting the holes for the AC lines to pass through the front of the Vanagon or at the very least measurements of where the holes are? and 2). I have one extra wire that is not shown on the wiring diagram. The wiring diagram shows a 4 position fuse block with only 3 fuses present. My wiring there is pretty standard and matches the wiring diagram. However, I have a 4th fuse with a single heavy (possibly 12 gauge) red with white stripe wire that is about 6" long with a female terminal on the end. It is in continuity with the battery power wires that power the other fuses but no clue as to where it goes. My old Air cooled unit doesn't have any such wire. Anyone have a clue? Thanks for the help if you can give it. Hayden |
I have one I took off one of my vans, an 84 automatic well, kinda, a friend did it on my request when I commissioned him to sell the van for me while I was abroad. I don't recall such wire. I can look see if he labelled it.... _________________ Silicone Steering Boots and 930 Cv boots for sale in the classifieds.
Syncro transmission upgrade parts in the Classifieds.
Subaru EJ22+UN1 5 speed transmission
http://www.thesamba.com/vw/forum/viewtopic.php?t=416343
Syncro http://www.thesamba.com/vw/forum/viewtopic.php?t=4...num+gadget |
|
Back to top |
|
|
WestyWanter Samba Member
Joined: February 15, 2017 Posts: 459 Location: San Diego
|
Posted: Fri Jun 24, 2022 11:20 pm Post subject: Re: Behr front AC unit questions |
|
|
I have the behr ac in my van, love it, what exactly do you need measured? Perhaps call SAH i'm pretty sure they did it on my van under the previous ownership. |
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32635 Location: Reading Pennsylvania
|
|
Back to top |
|
|
|