Author |
Message |
billgjcook1982 Samba Member
Joined: Yesterday Posts: 1 Location: United States
|
Posted: Yesterday 9:04 pm Post subject: 83 1.9L Vanagon L No Start Issue |
|
|
I'm in need of some knowledgeable Vanagon owners.
My wife and I recently bought a 83 1.9L Vanagon L. We have replaced the Alternator, starter, battery, hall module, ignition and switch, new power cable from battery to starter, replaced all the ground connectors (cleaned connections from tree to body under dash, fuel pump, transmission to chassis and chassis to engine head.) I've taken out the engine bay wiring harness and have ohm out every connector and replaced the ground connectors on that. I have everything working except the injectors, they function as I have taken them all out and tested and cleaned them. the issue is that I'm not getting the ground signal required for the injectors to fire. I've done all the test and diagnostics per the Bently manual. I've gotten the engine to run by grounding the center hall connector to the engine as it will fire the injectors and fuel pump, I can then go up and get the engine to fire up and run perfectly and it will keep running until I turn off the ignition and try to restart and the injectors no longer receive the ground signal. Tried a good ECU out of a running Vanagon and changed distributor.
Sorry for crazy book but hopefully I have covered all the bases. |
|
Back to top |
|
|
crazyvwvanman Samba Member
Joined: January 28, 2008 Posts: 9939 Location: Orbiting San Diego
|
Posted: Today 12:27 am Post subject: Re: 83 1.9L Vanagon L No Start Issue |
|
|
Open up the engine compartment wiring box, the one in the corner.
Inside there are 3 or 4 red wires attached to a threaded stud.
That is the main power junction for the engine in your year.
That stud should have power on it no matter the key position.
Keep measuring it while someone cranks the starter using the key.
The voltage should start off above 12v and not fall below 10v during cranking.
What do you see there?
Mark |
|
Back to top |
|
|
dobryan Samba Member
Joined: March 24, 2006 Posts: 16508 Location: Brookeville, MD
|
|
Back to top |
|
|
djkeev Samba Moderator
Joined: September 30, 2007 Posts: 32634 Location: Reading Pennsylvania
|
|
Back to top |
|
|
|