Hello! Log in or Register   |  Help  |  Donate  |  Buy Shirts  See all banner ads | Advertise on TheSamba.com  
TheSamba.com
 
Engine tin diagram?? Type IV
Forum Index -> Bay Window Bus Share: Facebook Twitter
Reply to topic
Print View
Quick sort: Show newest posts on top | Show oldest posts on top View previous topic :: View next topic  
Author Message
busmania
Samba Member


Joined: October 13, 2006
Posts: 1908
Location: Here
busmania is offline 

PostPosted: Thu Dec 04, 2008 4:24 pm    Post subject: Engine tin diagram?? Type IV Reply with quote

I searched the archives, technical section and the forums, after 10 pgs of reading, decided to make a post.

Got my longblock built. '72 upgraded to 1800. Looking at all of my freshly painted tin I am a little confused. I want to make sure I get every piece in place. Does someone have a good diagram of all of the tin? Bently section 5 page 20 has a decent diagram, but I feel like it is lacking?.

Also, what tin should be on the engine at this point? Again, it is built up to the heads. I have the 2 pieces of tin under the cylinders attached at this point. I thought I remember there being another piece of tin that (on the rear most part of the shroud side of the engine) could not come off until I remeved the right cylinder head. Am I crazy, or should there be another piece installed at this point?

Thanks everyone, Im hoping to have her running in the next two weeks.
Back to top
View user's profile Send private message Gallery Classifieds Feedback
jah_B
Samba Member


Joined: March 18, 2008
Posts: 1147
Location: Tempe, AZ
jah_B is offline 

PostPosted: Fri Dec 05, 2008 12:02 am    Post subject: Reply with quote

You'll have to register to use etka, but this has the microfiche for every year.. type 2 is at the bottom of the list.

http://www.vagcat.com/

Here's a couple from there for the '72 tins.. 'course seeing them in this diagram isn't much help in putting them all together...Tom Wilson's rebuild book gives some good tips on the order to install them..putting them on, then taking them apart and putting them back together in order SUCKS.... DAMHIK Laughing

OK Kombi is right.... you want the sections identified by by #10, and #13 in the 1st diagram, the other stuff is for a 1600. I gave you credit for being able to figure that out...and I was too lazy to photoshop it..

Image may have been reduced in size. Click image to view fullscreen.


Image may have been reduced in size. Click image to view fullscreen.


Once you get them all in place the way they are SUPPOSED to be....they make perfect sense.....but not until then... Cool
_________________
1984 CABRIOLET 6spd, quaife diff, Neuspeed springs, sway bars, tie bar, short shift kit, bilstein shocks, 16X7 RSE 3pc wheels, BFG TA 205 40s

1972 tintop P30 CAMPMOBILE: M/T, 1.7L, dual kadrons, 019 diz. Sunny the S'kool Bus


You gotta know what you don't know. That's the key to wisdom. man.


Last edited by jah_B on Fri Dec 05, 2008 8:33 am; edited 1 time in total
Back to top
View user's profile Send private message Gallery Classifieds Feedback
1975 Kombi
Samba Member


Joined: August 12, 2007
Posts: 2435
Location: Acton, Ontario, Canada
1975 Kombi is offline 

PostPosted: Fri Dec 05, 2008 7:19 am    Post subject: Reply with quote

Image may have been reduced in size. Click image to view fullscreen.


This might be easier to understand.
_________________
Brett

Hes decieving you boy! Reach into his pocket and take what hes got. Mr. Crabbs.

75 Westy auto
03 Jetta TDI
71 SB
74 Westy
Licensed pilot (single engine land VFR)
--
Rust In Peace: 72 Bug, 73 Bug, 81 Rabbit LS D 2D, 83 Rabbit D 2D, 84 Jetta TD GL, 85 Jetta D, 68 Z28 RS 302, 91 Passat 16v
Back to top
View user's profile Send private message Send e-mail Visit poster's website Gallery Classifieds Feedback
busmania
Samba Member


Joined: October 13, 2006
Posts: 1908
Location: Here
busmania is offline 

PostPosted: Fri Dec 05, 2008 10:01 am    Post subject: Reply with quote

Perfect. Where are these sorts of diagrams found? I know I have seen a lot of them around and I know I will be needing them in the future. Ill start saving them to my favorites page, but where can one quick reference these? Thanks.

Edit. Jah_b, thanks for that link. That is one of the most useful resources I have seen. Life will change for me now. Very Happy Thanks again.


Last edited by busmania on Fri Dec 05, 2008 10:08 am; edited 1 time in total
Back to top
View user's profile Send private message Gallery Classifieds Feedback
Karl
Samba Member


Joined: January 29, 2001
Posts: 6170
Location: Coos Bay, Oregon
Karl is offline 

PostPosted: Fri Dec 05, 2008 10:07 am    Post subject: Reply with quote

http://www.bus-boys.com/aircoolsystem.html
Back to top
View user's profile Send private message Gallery Classifieds Feedback
busmania
Samba Member


Joined: October 13, 2006
Posts: 1908
Location: Here
busmania is offline 

PostPosted: Fri Dec 05, 2008 11:01 am    Post subject: Reply with quote

Thanks Karl, that is also very useful to know. They have some parts I have been looking for such as some of the small rubber grommets and such.
Back to top
View user's profile Send private message Gallery Classifieds Feedback
Display posts from previous:   
Reply to topic    Forum Index -> Bay Window Bus All times are Mountain Standard Time/Pacific Daylight Savings Time
Page 1 of 1

 
Jump to:  
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum

About | Help! | Advertise | Donate | Premium Membership | Privacy/Terms of Use | Contact Us | Site Map
Copyright © 1996-2020, Everett Barnes. All Rights Reserved.
Not affiliated with or sponsored by Volkswagen of America | Forum powered by phpBB