Author |
Message |
dubsteez79 Samba Member
Joined: November 22, 2017 Posts: 194 Location: star nc
|
Posted: Mon Jul 22, 2019 7:45 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
|
|
Back to top |
|
|
flat4olsen Samba Member
Joined: February 20, 2014 Posts: 342 Location: Denmark, Europe
|
Posted: Mon Jul 22, 2019 8:37 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
_________________ Type 1 1968, Lotosweiss. 2109 oxyboxer engine
Early Bay 1970, Montana Red. Under construction |
|
Back to top |
|
|
challomoner Samba Member
Joined: October 13, 2010 Posts: 1215 Location: IRELAND
|
Posted: Mon Jul 22, 2019 9:07 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
|
|
Back to top |
|
|
manoteal Samba Member
Joined: November 15, 2010 Posts: 126 Location: San Diego, CA
|
Posted: Sat Aug 17, 2019 4:39 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
1969 bug with 1973 block, Stock Dual-port with heads/valves done by friend who has machine shop- guides replaced and seats/valves ground to spec.
34 PICT-3 rebuilt by Keifernet with rebushed throttle shaft and riveted plate hole. This one was on my Super beetle before I crashed that car in 2012.
AirCooledNet SVDA Distributor with Pertronix I from 2010- Still like new!
Stock Muffler with original German heater boxes.
VW Paradise (now Paradise Motorsports) of San Marcos bottom end- fixed spun bearing on #1 and polished and put in new Silverline bearings on crank/rods.
Replaced terrible cheap flywheel with good German one from Interstate Auto in Lake Elsinore.
Blue Coil (Brazil) painted black for ‘stealth’.
Got original air cleaner for 1973 from classifieds here.
Valve on vacuum line to air cleaner thermostat is to shut off hot air to carb on hot days (thermostat flap works but stays closed- hot air- all the time due to stuck thermostat). I leave it open to warm up the car and then shut it off after the motor is hot. On cool days or night driving I just leave it open (Preheat on).
Uses ‘waste air’ gauge under cylinders for temperature sensing. Dipstick sender bent and put through grommet in rear tin hole and under #2 cylinder.
Has Flaps and thermostat for proper warm up.
With stock ‘69 unvented engine cover- I use 3” modified ‘tennis ball trick’ for cooling.
Runs like a top with 27MPG average City/Hwy at 60 MPH on freeway.
Comments welcomed.
|
|
Back to top |
|
|
Glenn Mr. 010
Joined: December 25, 2001 Posts: 76937 Location: Sneaking up behind you
|
Posted: Sat Aug 17, 2019 5:02 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
_________________ Glenn
74 Beetle Specs | 74 Beetle Restoration | 2180cc Engine
"You may not get what you pay for, but you always pay for what you get"
Member #1009
#BlueSquare |
|
Back to top |
|
|
Tim Donahoe Samba Member
Joined: December 08, 2012 Posts: 11740 Location: Redding, CA
|
Posted: Sat Aug 17, 2019 5:02 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
Looking good. The only thing I’d change is getting a new air-cleaner thermostat. I believe Rock Auto still sells them for the Rabbit, which is the same as on our later Bugs.
Tim _________________ Let's do the Time Warp again!
Richard O'Brien |
|
Back to top |
|
|
RailBoy Samba Member
Joined: March 10, 2008 Posts: 2904 Location: Virginia
|
Posted: Sat Aug 17, 2019 5:06 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
Check out the Carbs, not many doing that, maybe not until now! lol... RB
_________________ [quote="smitty24"]"HELP, I ported my own heads and now have fire coming out my ass" .[/quote]
|
|
Back to top |
|
|
sb001 Samba Member
Joined: May 19, 2011 Posts: 10406 Location: NW Arkansas
|
Posted: Sat Aug 17, 2019 5:08 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
_________________ I'm the humblest guy on this board.
1969 autostick sedan, family owned since new
1600 SP engine
Solex 30 PICT 3 carburetor
Bosch 113905205AE autostick distributor |
|
Back to top |
|
|
Glenn Mr. 010
Joined: December 25, 2001 Posts: 76937 Location: Sneaking up behind you
|
Posted: Sat Aug 17, 2019 5:10 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
_________________ Glenn
74 Beetle Specs | 74 Beetle Restoration | 2180cc Engine
"You may not get what you pay for, but you always pay for what you get"
Member #1009
#BlueSquare
Last edited by Glenn on Sat Aug 17, 2019 5:11 pm; edited 1 time in total |
|
Back to top |
|
|
manoteal Samba Member
Joined: November 15, 2010 Posts: 126 Location: San Diego, CA
|
Posted: Sat Aug 17, 2019 5:10 pm Post subject: Engine bay |
|
|
Thermostat on order.
Bought all new hoses and wires and plugs-
Ready to go soon with upgrades!
Last edited by manoteal on Wed Aug 21, 2019 11:50 pm; edited 2 times in total |
|
Back to top |
|
|
wcfvw69 Samba Purist
Joined: June 10, 2004 Posts: 13389 Location: Arizona
|
Posted: Sat Aug 17, 2019 9:21 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
_________________ Contact me at [email protected]
Follow me on instagram @sparxwerksllc
Decades of VW and VW parts restoration experience.
The Samba member since 2004.
**Now rebuilding throttle bodies for VW's and Porsche's**
**Restored German Bosch distributors for sale or I can restore yours**
**Restored German Pierburg fuel pumps for sale or I can restore yours**
**Restored Porsche fuel pumps or I can restore yours**
**Restored Porsche distributors or I can restore yours** |
|
Back to top |
|
|
calvinater Samba Member
Joined: September 06, 2014 Posts: 3329 Location: 802 The Pointless Forrest
|
Posted: Sun Aug 18, 2019 3:01 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
Tim Donahoe wrote: |
Looking good. The only thing I’d change is getting a new air-cleaner thermostat. I believe Rock Auto still sells them for the Rabbit, which is the same as on our later Bugs.
Tim |
Got a part number for that? _________________ "Albatross"! |
|
Back to top |
|
|
manoteal Samba Member
Joined: November 15, 2010 Posts: 126 Location: San Diego, CA
|
Posted: Sun Aug 18, 2019 3:58 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
Rock Auto-VW 038129828=$86.29 Gr
“ VW 035129630B= $98.79 Bl
AutoZone SU8153=$71.99 Gr
“ SU8654=$137.99 Bl
O’Reilly. ATS35=$64.99 Gr
Express OEM PARTS 035-129-630B =$84.23 Bl
“. 038-129-828= $78.87 Gr
(Has Lock plate and gasket too
Plate 113-129-830= $3.57
Gasket. 113-129-832=$1.67
Parts Vortex. 035-129-630B=$82.52 Bl
“. 038-129-828=$78.20 Gr
Clip and gasket same numbers and approx same prices here.
The two last ones are genuine VW shops so have clips and gasket if needed
Amazon has the thermostats, too. Try same numbers.
Gr= green body with plastic hose connectors.
Bl= black body ( like stock) and one brass and one plastic connector.
The O’Reilly one is the best value and same as the other Green ones.
On AutoZone and O’Reilly they say they will not work for 1973/74, but they do.
Hope this helps.
Last edited by manoteal on Sun Aug 18, 2019 4:09 am; edited 2 times in total |
|
Back to top |
|
|
sb001 Samba Member
Joined: May 19, 2011 Posts: 10406 Location: NW Arkansas
|
Posted: Sun Aug 18, 2019 4:01 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
Calvinater, try a google search for VW part number 113 129 828. _________________ I'm the humblest guy on this board.
1969 autostick sedan, family owned since new
1600 SP engine
Solex 30 PICT 3 carburetor
Bosch 113905205AE autostick distributor |
|
Back to top |
|
|
sb001 Samba Member
Joined: May 19, 2011 Posts: 10406 Location: NW Arkansas
|
Posted: Sun Aug 18, 2019 4:30 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
manoteal wrote: |
Rock Auto-VW 038129828=$86.29 Gr
“ VW 035129630B= $98.79 Bl
AutoZone SU8153=$71.99 Gr
“ SU8654=$137.99 Bl
O’Reilly. ATS35=$64.99 Gr
Express OEM PARTS 035-129-630B =$84.23 Bl
“. 038-129-828= $78.87 Gr
(Has Lock plate and gasket too
Plate 113-129-830= $3.57
Gasket. 113-129-832=$1.67
Parts Vortex. 035-129-630B=$82.52 Bl
“. 038-129-828=$78.20 Gr
Clip and gasket same numbers and approx same prices here.
The two last ones are genuine VW shops so have clips and gasket if needed
Amazon has the thermostats, too. Try same numbers.
Gr= green body with plastic hose connectors.
Bl= black body ( like stock) and one brass and one plastic connector.
The O’Reilly one is the best value and same as the other Green ones.
On AutoZone and O’Reilly they say they will not work for 1973/74, but they do.
Hope this helps. |
Wow. _________________ I'm the humblest guy on this board.
1969 autostick sedan, family owned since new
1600 SP engine
Solex 30 PICT 3 carburetor
Bosch 113905205AE autostick distributor |
|
Back to top |
|
|
manoteal Samba Member
Joined: November 15, 2010 Posts: 126 Location: San Diego, CA
|
Posted: Sun Aug 18, 2019 9:32 am Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
After reading all the links for all the parts and looking up all the vendors, I thought I would ‘share the wealth ‘ of what I found.
Enjoy!
Mark
|
|
Back to top |
|
|
Zundfolge1432 Samba Member
Joined: June 13, 2004 Posts: 12467
|
Posted: Sun Aug 18, 2019 12:36 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
1600 DP driven hard put away wet often. |
|
Back to top |
|
|
Zundfolge1432 Samba Member
Joined: June 13, 2004 Posts: 12467
|
Posted: Sun Aug 18, 2019 12:48 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
1600 DP driven hard put away wet often. |
|
Back to top |
|
|
manoteal Samba Member
Joined: November 15, 2010 Posts: 126 Location: San Diego, CA
|
Posted: Sun Aug 18, 2019 3:17 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
What’s the difference between the green and black vacuum hoses?
The reason I ask is that the nipple on the intake manifold below the carburetor is larger than the nipple on the thermostat in air cleaner and I find it hard to get a ‘best fit’ on both.
Also, I have noticed that sometimes the black hose is conductive and sparks can be ‘grounded’ though its high carbon content?
Anyone else notice this and resort to rubber hose between air cleaner and manifold connection?
Thanks _________________ 1969 bug with original Riviera wheels- daily driver.
'73 1600 DP- AD case
Solex 34 PICT-3 Carb by Keifernet
Bosch 034 SVDA dizzy by ACN
(2002 Honda Accord for parts runs) |
|
Back to top |
|
|
Xevin Samba Member
Joined: January 08, 2014 Posts: 7628
|
Posted: Sun Aug 18, 2019 4:27 pm Post subject: Re: Show off your engine bay! - Post your pics!! |
|
|
Not sure why VW used green hose. I was told by the boys at Avery’s Air-cooled that originally 73-74 bugs came with 2 green vacuum hoses
So that’s what I run. _________________ Keep on Busin'
67rustavenger wrote: |
GFY's Xevin and VW_Jimbo! |
Clatter wrote: |
Damn that Xevin... |
skills@eurocarsplus wrote: |
I respect Xevin and he's a turd |
SGKent wrote: |
My God! Xevin and I 100% agree |
|
|
Back to top |
|
|
|