Author |
Message |
surfbus23 Samba Member
Joined: July 21, 2016 Posts: 383
|
Posted: Sun Jan 24, 2021 10:47 am Post subject: Starter solenoid terminal snapped off. What now? |
|
|
Was under the bus to hook up a new wire for headlights to my starter solenoid terminal. It moved and froze for a second, so without thinking about it I gave it some force and the entire #30 post off the plastic top.
Can someone advise as to what my options are? I assume replacing the part is a must, but is there anyway I can fix this for a quick emergency?
Thanks,
K
|
|
Back to top |
|
|
SGKent Samba Member
Joined: October 30, 2007 Posts: 41031 Location: Citrus Heights CA (Near Sacramento)
|
Posted: Sun Jan 24, 2021 11:08 am Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
pull the starter and replace the solenoid. Be sure you get the correct one. Or replace the starter. Your solenoid has multiple blade connectors on it.
Also pull the battery connection NOW if you haven't already before that hits something and burns the bus up. _________________ “Most people don’t know what they’re doing, and a lot of them are really good at it.” - George Carlin
Last edited by SGKent on Sun Jan 24, 2021 11:10 am; edited 1 time in total |
|
Back to top |
|
|
surfbus23 Samba Member
Joined: July 21, 2016 Posts: 383
|
Posted: Sun Jan 24, 2021 11:09 am Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
Pulled. I know this is a silly question, but how do I know it's the correct one. I happen to be in Costa Rica right now, so I'm not sure what availability is going to be like. |
|
Back to top |
|
|
SGKent Samba Member
Joined: October 30, 2007 Posts: 41031 Location: Citrus Heights CA (Near Sacramento)
|
Posted: Sun Jan 24, 2021 11:10 am Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
surfbus23 wrote: |
Pulled. I know this is a silly question, but how do I know it's the correct one. I happen to be in Costa Rica right now, so I'm not sure what availability is going to be like. |
fairly common solenoid. _________________ “Most people don’t know what they’re doing, and a lot of them are really good at it.” - George Carlin |
|
Back to top |
|
|
surfbus23 Samba Member
Joined: July 21, 2016 Posts: 383
|
Posted: Sun Jan 24, 2021 11:20 am Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
Ok. I like to hear that. Figured it's gotta be pretty common. Was my mistake for not protecting the connections with dialectic grease.
While we're at it. What's the cause of this carbon build up on the starter?
Thanks!
|
|
Back to top |
|
|
raygreenwood Samba Member
Joined: November 24, 2008 Posts: 21519 Location: Oklahoma City
|
Posted: Sun Jan 24, 2021 11:36 am Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
The carbon.....is likely clutch dust and oil.
As for dielectric grease.....yes.....but ONLY sla5her it on the outside of the connections after they are connected and tightened down.
Too many people fail to realize that dielectric grease.....is a DIELECTRIC....meaning insulator....non-conductor. Its primary ingredient is silica and/or silicone. They do not conduct electricity. They make for high resistance connections.
Ray |
|
Back to top |
|
|
surfbus23 Samba Member
Joined: July 21, 2016 Posts: 383
|
Posted: Sun Jan 24, 2021 11:40 am Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
Thanks Ray. Always appreciate your guidance. Headed out to have it repaired now. Will report back. |
|
Back to top |
|
|
surfbus23 Samba Member
Joined: July 21, 2016 Posts: 383
|
Posted: Sun Jan 24, 2021 1:14 pm Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
Buenas noticias! Miraculously, the guy had an exactly one German replacement that he'd been sitting on for 10 years. He swapped it out and I'm good to go. |
|
Back to top |
|
|
SGKent Samba Member
Joined: October 30, 2007 Posts: 41031 Location: Citrus Heights CA (Near Sacramento)
|
Posted: Sun Jan 24, 2021 1:36 pm Post subject: Re: Starter solenoid terminal snapped off. What now? |
|
|
awesome _________________ “Most people don’t know what they’re doing, and a lot of them are really good at it.” - George Carlin |
|
Back to top |
|
|
|