Author |
Message |
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Sat Apr 18, 2020 4:46 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Cleaning up some interior panels that I got a few months ago.
It took me a minute to figure out that my front doors and rear hatch use a press-in style clip, and the cargo interior panels use a screw style. WW descriptions threw me off.
**** BEFORE ****
**** AFTER ****
**** MACHO SUN TANNING ON PANELS ****
_________________ http://www.vw-trader.com |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Fri May 01, 2020 8:10 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Finally. 7 months later.
I’ll post a few updates this weekend, but here’s a few seconds of my first drive after 7 months of slowly tinkering, having things done when I can... and a lot of patience.
Welcome to mi barrio
Link
_________________ http://www.vw-trader.com |
|
Back to top |
|
|
BarryL Samba Member
Joined: November 01, 2004 Posts: 14258 Location: Casa de Oro, California
|
Posted: Sat May 02, 2020 11:25 am Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
That thing sounds gooood. |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Sun May 10, 2020 3:49 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
- Got the cargo door panels in. I need to heat up the center bulkhead panel to form it back curved then those will go in.
- Went on a drive and MELTED a fuse! I’ll dig into this soon. It happened a few minutes after turning on headlights...
- Gear oil was leaking from reduction box, fixed.
- Now other side is leaking...will look into soon.
- Here’s a few parts I got recently.
- Time to start working on the parcel tray.
Link
_________________ http://www.vw-trader.com |
|
Back to top |
|
|
Eric&Barb Samba Member
Joined: September 19, 2004 Posts: 24736 Location: Olympia Wash Rinse & Repeat
|
Posted: Sun May 10, 2020 5:06 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
What wattage of headlight bulbs are you using??
Do not use the headlights till you get this sorted out! _________________ In Stereo, Where Available! |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Sun May 10, 2020 6:15 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Eric&Barb wrote: |
What wattage of headlight bulbs are you using??
Do not use the headlights till you get this sorted out! |
I’m assuming 12v but I’ll check tomorrow... _________________ http://www.vw-trader.com |
|
Back to top |
|
|
Eric&Barb Samba Member
Joined: September 19, 2004 Posts: 24736 Location: Olympia Wash Rinse & Repeat
|
Posted: Sun May 10, 2020 6:32 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
volkswagen60 wrote: |
Eric&Barb wrote: |
What wattage of headlight bulbs are you using??
Do not use the headlights till you get this sorted out! |
I’m assuming 12v but I’ll check tomorrow... |
Watts = Volts x Amps
So 12 volt or 6 volt is not the concern.
If 60 Watt bulbs = 12 volt x 5 Amps
or 60 Watt = 6 volt x 10 Amps
Original VW headlight bulbs were 40 Watt low beam & 45 Watt high beam.
Later FLAPS replacements where 50/55 Watt.
When we went to H-4s those started out at 55/60 Watt. _________________ In Stereo, Where Available! |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Sun May 10, 2020 6:59 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Eric&Barb wrote: |
volkswagen60 wrote: |
Eric&Barb wrote: |
What wattage of headlight bulbs are you using??
Do not use the headlights till you get this sorted out! |
I’m assuming 12v but I’ll check tomorrow... |
Watts = Volts x Amps
So 12 volt or 6 volt is not the concern.
If 60 Watt bulbs = 12 volt x 5 Amps
or 60 Watt = 6 volt x 10 Amps
Original VW headlight bulbs were 40 Watt low beam & 45 Watt high beam.
Later FLAPS replacements where 50/55 Watt.
When we went to H-4s those started out at 55/60 Watt. |
Edited: 1 headlamp is GE #6012 (50/40 watt??), the other is a GE 2D1 headlamp (65/35??). _________________ http://www.vw-trader.com |
|
Back to top |
|
|
Eric&Barb Samba Member
Joined: September 19, 2004 Posts: 24736 Location: Olympia Wash Rinse & Repeat
|
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Sat May 16, 2020 1:34 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
A few tidbits today.
- Lesson learned. Make sure you line up the front window felt with the metal slotted bracket to make sure slots line up I had to trim a bit more.
- Pretty sure this is too many wires going to the melty fuse terminal
- Rear hatch panel is in.
- I bought this carpet from Home Depot for $18. Fits pretty good. I'm going to buy another for under the seat.
_________________ http://www.vw-trader.com |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Wed May 20, 2020 12:11 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Decided to replace speedometer cable while I wait to do rear axle leak and tackle melting fuse issue...
- Speedometer cable end was shredded.
- New cable seems to work pretty good and gauge looks accurate!
Link
_________________ http://www.vw-trader.com |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Sun Jun 28, 2020 12:24 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Bus took a turn over the past 2 months.
Local students are using the bottom half of the bus as an art canvas!
Check out their artwork....more to come!
fb.com/Mountain-House-VW-Art-Bus-108733194109122
_________________ http://www.vw-trader.com |
|
Back to top |
|
|
vwuberalles Samba Member
Joined: October 18, 2003 Posts: 1357 Location: Richmond, VA
|
Posted: Mon Jun 29, 2020 7:59 am Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Awesome paint job! The kids must be having a blast! Many years ago I used to volunteer at this summer camp thing for kids. I drove my 67 bus with the bottom half in red primer a lot back then, so I'd let the kids decorate it with chalk. They had so much fun! _________________ 1973 Superbeetle: 1st car, owned since age 12. Update thread --> https://www.thesamba.com/vw/forum/viewtopic.php?p=9919140#9919140
1967 Kombi: Owned since age 17, Dad's retirement project.
1966 Beetle: My new project. (SOLD) Build thread--> https://www.thesamba.com/vw/forum/viewtopic.php?t=678040 |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Tue Jul 28, 2020 6:45 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
vwuberalles wrote: |
Awesome paint job! The kids must be having a blast! Many years ago I used to volunteer at this summer camp thing for kids. I drove my 67 bus with the bottom half in red primer a lot back then, so I'd let the kids decorate it with chalk. They had so much fun! |
They had a blast! We also just did the Farmer's Market where they sold paintings and other artsy stuff... new post coming soon _________________ http://www.vw-trader.com |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Tue Jul 28, 2020 6:54 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
I'll post mechanical and cosmetic updates next week, but for this week it's all about the local student artists who painted my bus.
They sold their paintings, hand painted magnets, flower pots, tie dye shirts, and displayed the bus at the Farmer's Market! So proud!
_________________ http://www.vw-trader.com |
|
Back to top |
|
|
BarryL Samba Member
Joined: November 01, 2004 Posts: 14258 Location: Casa de Oro, California
|
Posted: Wed Jul 29, 2020 6:13 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Seriously rad art. |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
Posted: Wed Jul 29, 2020 6:28 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
BarryL wrote: |
Seriously rad art. |
Thanks, it is. Kids did an awesome job. Talent. _________________ http://www.vw-trader.com |
|
Back to top |
|
|
GERMANAIRE Samba Member
Joined: August 25, 2007 Posts: 689 Location: BUFORD,GA.
|
Posted: Wed Jul 29, 2020 7:50 pm Post subject: Re: Tinkering With 66...BusOnABudget |
|
|
Congrats on the Bus! Glad to see you are enjoying it. Sweet Art Work and my Hat is off to you for letting them express themselves on it. Some talented kids right there Looking Good, keep up the good work. Will definitely continue to follow your progress. |
|
Back to top |
|
|
volkswagen60 Samba Member
Joined: August 10, 2005 Posts: 326
|
|
Back to top |
|
|
LAGrunthaner Samba Member
Joined: March 18, 2007 Posts: 5506 Location: 1st Coast
|
|
Back to top |
|
|
|