Bedliner on exterior

[Trash Vanda]

I have seen a lot of people do spray-on bedliner (Raptor, etc) on the bumpers and lower exterior trim. I like the way it looks and my 1997 could use a little refresh, but I have some questions:

1. Does it actually protect the vehicle in any meaningful way, or is it just aesthetic? I take the van on a lot of forest roads (PNW), but let's be real this is not an offroad vehicle. Does liner really protect the van in such cases or is it just cosmetic?

2. If I do it myself, do I have to remove the bumpers to get a good effect? I've seen online some people spray it directly onto the vehicle with bumpers intact (with a lot of careful masking). Does it matter?

3. I'm planning to add aftermarket fender flares as well. Can I put these on first and then spray liner all over it, or should I do the liner first and then the flares on top of that?

Thanks!
_________________
'97 EVC

[Zeitgeist 13]

A quality bedliner is pretty tough and should protect against stone-chipping, low-speed branch damage and just overall road debris. Personally, I just brush it on using strokes all running one direction. When my wife got rear-ended up in Seattle, I resuscitated the fr/rr bumper covers using heat and a plastic welder. I then brushed bedliner on the complete rear cover and just the bottom on the front. That was about six years ago. It's mostly held up except for some small sections where adhesion to the plastic wasn't fully complete. The color will fade a bit with exposure to direct sunlight.

I've been meaning to bedline the rocker panels, but there's some body work required before I apply such a nuisance to remove product. You definitely don't want to paint it over rust, as that's just asking for trouble down the road.

_________________
Casey--

'89 Bluestar ALH
'01 Weekender --> full camper
NEAT, no ICE.

[Stinky123]

I dunno....but, I have a gallon of it right now. I have an '86 Dodge B300 that was an Aspen ambulance....it needs a bunch of work. It has some cancer down low. That part of the van has been painted black....from 2" high (above the wheels) to 8-10" high (on the rest of it). I'm going to give a bed liner coating on that part of the van a try.

Oh, it has 56K on it.

[Damian Shaw]

[Trash Vanda]

[Trash Vanda]

[Zeitgeist 13]

[mikemtnbike]

I’ve been using these “flares” for about 4 years and they’ve been great. Clip on and don’t fall off, I drive a good bit of washboard gravel to go camping and mountain biking.
https://www.busdepot.com/j12150

Another thing I like about this is you can do the bedliner look without having to worry about about the wheel arches as much- fewer curves. Spray can bedliner.

_________________
1991 Vanagon GL 2.1 AT Westfauxlia. "Frankie" Totaled https://www.thesamba.com/vw/forum/viewtopic.php?t=764510&highlight=carnage
1995 Eurovan Camper "Marzivan"
2020 GTI SE manual

[Endopotential]

Dunno if it's just the brand applied to mine, but I find that mud or dirt gets embedded into the textured surface and is impossible to scrub out. It's just a light film that I choose not to let bother me.

_________________
2002 Eurovan Weekender

[HeyCrutch]

Reason #1 for spraying bedliner along the side sills ... it hides all the damaged jack point pinch welds.

Can't be bothered by what you can't see

Happy Thanksgiving!
_________________
-2003 EV MV Wk - Forest - 51k
-2002 EV Camper - Ghost - 82k
-2003 EV GLS - Fluffhead - 176k

-1997 EVC - 12vVR6 (SOLD 5/2025)